Incineration of organic waste liquor

I. Overview

By using carbonization and pyrolysis technology, Japanese liquid incineration technology and traditional waste liquid incineration technology, harmful compounds such as chlorine, benzene and phenols in waste liquor are fully decomposed, especially for the treatment of high concentration organic waste liquor and high salinity wastewater. It is widely used in petroleum, chemical, pharmaceutical and electronic industries. Chemical, pesticide, plastics, pharmaceutical coating industry is a harmless disposal measure of waste liquid which can not be replaced by traditional water treatment and biochemical disposal.

II. Technical Characteristics

The tangential atomizing device, internal mixing two fluid atomizer, has high mixing degree, atomization effect, high burning rate and efficiency, and low excess air coefficient. It can save a large amount of fuel consumption. The atomizer has a large caliber, and has low requirement for fluid viscosity and impurity content, and is not easy to block. High pressure spray gun type is safe, not easy to wear, not easy to break down, good combustion effect, atomizing medium can be used low pressure steam or air;

Low nitrogen combustion technology, using patented atomizing spray gun, its mixing degree and combustion rate is very high, organic matter decomposition is thorough;

Eddy current design, combustion time more than 2 seconds, no dead angle combustion;

Waste liquid, waste water and waste oil can be treated at the same time to make waste. The operation cost is low and the value of waste heat utilization is high.

According to the characteristics of wastewater composition, a special incinerator for saline wastewater was designed by using low temperature carbonization and Japanese liquid incineration technology, which effectively and thoroughly solved the wall blockage caused by domestic treatment of saline wastewater and realized the continuous and stable operation of the equipment.

Wastewater incinerator can treat organic waste gas and a small amount of solid waste while treating wastewater.

III. Scope of application

High concentration BOD, COD organic wastewater, chemical waste liquor, factory odor, organic waste liquor, waste acid, waste alkali, waste gas, etc.

IV. Processing Capacity

50-15 000 kg/h